Entries
ITB00-063b
-REVISED-
2000-2001 INFINITI I30; BRAKE JUDDER
Brake judder may be described as steering wheel/body vibration or brake pedal pulsation when braking
(especially during high speed braking). Brake judder may be created by excessive “thickness variation” of the
brake rotors.
05-25-2002
173.37 Kbytes
Hits 34
Keywords:
brake judder
ITB02-032
2001 INFINITI I30, 2002 I35; REAR SUSPENSION BOTTOMS OUT
If, while driving an applied model under the following conditions:
• over bumps or dips in the road and
• with the vehicle loaded (4-5 occupants and/or heavy load in the cargo area)
ITB02-031
ALL INFINITI MODELS; PLASTIC HEADLAMP LENS CLEANER
This bulletin introduces 3M Plastic Polish # 39010, which should be used to clean and polish headlamps
with cloudy, hazy, or other poor appearance.
ITB01-022a
-REVISED-
2000-2001 INFINITI I30, 2002 I35; WIND NOISE REAR DOOR GLASS
If a vehicle listed above has a hiss, whistle, or flutter noise from the rear door glass area (left, right, or both
sides) at 40 MPH or more, determine if there is:
• Too much clearance between the rear door glass run rubber and top corner of the window “partition sash”
(next to the fixed quarter window) causing a wind leak.
ITB02-019
2001-2002 ALL INFINITI MODELS, 2003 G35; TACHOMETER NEEDLE ON WRONG SIDE OF STOP PIN
If an Applied Vehicle displays the following symptom:
• The Tachometer Needle is on the wrong side of the stop pin
ITB02-016
VARIOUS INFINITI MODELS; SEATBACK BOARD REMOVAL PROCEDURE
Use the procedure in this bulletin to properly remove the “seatback board” on a left or right front seat when a
repair requires access to the inner seatback on an applied model.
ITB02-015
1998-2002 ALL INFINITI MODELS; DTC 1491 (VACUUM CUT VALVE BYPASS VALVE)
DIAGNOSIS
This bulletin is an aid to the diagnostic procedures in the Service Manual for DTC P1491.
03-22-2002
117.63 Kbytes
Hits 198
Keywords:
dtc mil p1491
ITB01-061a
-REVISED-
2001 INFINITI I30, 2002 I35, AND 2001-2002 G20; REAR CALIPER CLUNK, RATTLE, OR KNOCKING NOISE
If an Applied 2001 I30, 2002 I35, or 2001-2002 G20 exhibits the following symptoms:
• A clunk, knock, or rattle noise from the rear of the vehicle while driving on rough road surfaces or over
harsh bumps
ITB02-005
2001 INFINITI I30; LOW/NO IDLE AFTER COLD START
If a 2001 I30 has the following symptoms:
• The engine idle drops excessively or stops when engine is started cold;
• This incident is not A/T related, and may be occurring within the first 10 seconds after the engine is started
cold; and
• Once the engine warms, the incident no longer occurs
01-23-2002
90.40 Kbytes
Hits 58
Keywords:
engine idle
ITB01-072a
-REVISED-
2000-2001 INFINITI I30; EGI HARNESS WIRE BREAKAGE
If a 2000-2001 I30 has any of the following symptoms:
• MIL 'On' and/or Diagnostic Trouble Code (DTC) stored in Self-Diagnosis,
• Engine no start,
• Other system malfunctions such as A/C inop, A/C idle up inop, rough idle, oil pressure light inop